replacing of OPC cement by Fly Ash with grade M35 along

specializing in the production of large, medium and small concrete mixers, concrete mixing stations, stabilized soil mixing stations and other equipment. It is a heavy industry enterprise integrating R & production and sales.

replacing of OPC cement by Fly Ash with grade M35 along ...

• For M-35 grade of concrete with 10% replacement of sand by crusher stone dust along with 20% replacement of opc cement by fly ash gives

Get PriceEmail Inquiry

z222 Comparative Study on Strength and Water Absorption of ...

replacement levels in M25, M30, M35 and M40 and the optimum level of fly ash replacement was 55%. 4. Materials Used A. Ordinary Portland cement (OPC) The

Get PriceEmail Inquiry

Performance Evaluation of M35 Grade Concrete Paver Blocks ...

Aggarwal P. et al; [5], studied the effect of bottom ash as replacement of fine aggregates in concrete at 10%, 20%, 30%, 40% and 50% replacement level. OPC 43

Get PriceEmail Inquiry

Mix Design of Grade M35 by Replacement of Cement with

characteristics of control concrete of grade M35 and RHA concrete produced by replacing cement by raw RHA in different percentage (0%, 5%, 10%, 15%).

Get PriceEmail Inquiry

Flyash Replacement of Cement in Concrete Fly Ash Concrete

Reinforced cement concrete code of practice, fly ash (conforming to IS 3812 part 1) up to 35% can be used as part replacement of OPC in the concrete. As

Get PriceEmail Inquiry

Chapter 3 - Fly Ash in Portland Cement Concrete - Fly Ash ...

Jun 27, 2017  The replacement of cement by fly ash reduces the water demand for a given slump. When fly ash is used at about 20 percent of the total cementitious, water demand is reduced by approximately 10 percent. Higher fly ash contents will yield higher water reductions. The decreased water demand has little or no effect on drying shrinkage/cracking.

Get PriceEmail Inquiry

‪Prarthita Basu‬ - ‪Google Scholar‬

Study compressive strength characteristics of concrete by partially replacing of OPC cement by Fly Ash with grade M35 along with partial replacement of Natural sand by varying P Basu 2016

Get PriceEmail Inquiry

Performance Evaluation of M35 Grade Concrete Paver Blocks ...

Apr 16, 2021  Aggarwal P. et al; [5], studied the effect of bottom ash as replacement of fine aggregates in concrete at 10%, 20%, 30%, 40% and 50% replacement level. OPC 43 grade cement was used as a binding material. It was observed that the workability decreases with increase in the percentage replacement of bottom ash in concrete.

Get PriceEmail Inquiry

Mix Design of Grade M35 by Replacement of Cement with

characteristics of control concrete of grade M35 and RHA concrete produced by replacing cement by raw RHA in different percentage (0%, 5%, 10%, 15%). Objectives of the Study The primary aim of experimental work is to study the properties of rice husk ash. Preparation of mix design replacement of cement with RHA as different proportions with ...

Get PriceEmail Inquiry

Project on Concrete Mix Design for various grades of ...

Feb 26, 2021  Aim: To determine the mix design for M35 concrete with fly ash consisting of the following properties: Grade designation : M35 Type of cement : OPC 43 grade confirming IS 12269 Type of mineral admixture : Fly ash Maximum nominal size of aggregate : 20 Minimum water-cement ratio : 0.45 (Table 5 of IS 456:2000) Workability

Get PriceEmail Inquiry

Exploration of Properties of Concrete by Partial ...

Feb 22, 2020  Prarthita Basu (2016) Study compressive strength characteristics of concrete by partially replacing of ordinary Portland cement (OPC) with fly ash by using grade M35 along with partial replacement of natural sand by varying percentage of crusher dust and marble waste dust International Research Journal of Engineering Technology (IRJET), Vol ...

Get PriceEmail Inquiry

Influence of fly ash on concrete – A systematic review ...

Jan 01, 2020  On the other hand, M35 grade of concrete mix with 30% fly ash replacement showed the highest flexural strength after 28 days. Mohammad Abushad, Misbah Danish Sabri. Comparative Study of Compressive Strength of Concrete with Fly Ash Replacement by Cement. OPC 53 grade cement is used. The experiment is carried out with M25 grade concrete.

Get PriceEmail Inquiry

Flyash Replacement of Cement in Concrete Fly Ash Concrete

Reinforced cement concrete code of practice, fly ash (conforming to IS 3812 part 1) up to 35% can be used as part replacement of OPC in the concrete. As per the note of table 5 of this code of practice, addition of fly ash quantity can be taken into account in the concrete composition with respect to cement content and water cement ratio.

Get PriceEmail Inquiry

Compressive Strength of Concrete with Partial Replacement ...

This paper present the experimental result carried out to determine workability and compressive strength of concrete at different replacement of PPC. M-25 grade of concrete (1:1.53:3) at w/c of 0.42 was designed as per IS-10262-2009. Result shows that PPC can be replaced up to 20% by fly ash without compromising compressive strength of concrete.

Get PriceEmail Inquiry

Can we mix OPC and PPC cement for concrete? - Quora

There is no problem to mix OPC and PPC technically if you will select right proportion to achieve desired compressive strength and durability parameters according to the structural requirement. PPC is batched by blending OPC cement with pozzolonic...

Get PriceEmail Inquiry

Research Consultancy - Kautilya

Study of strength and properties of cement concrete M-35 M-40 under the influence of addition partially replacing cement with fine ground granulated blast furnace slag and flyash Study characteristics of concrete by partially replacing of OPC cement by Fly Ash with grade M30 M35 along with partial replacement of Natural sand by varying ...

Get PriceEmail Inquiry

UTILIZATION OF POND ASH AS PARTIAL REPLACEMENT OF CEMENT

partially with cement and pond fl y ash as a replacement of. fine aggregate. In mix G1, G2, G3 we will repla ce cement with. alccofine 4% and fine fly ash 26% and pond fly ash varies. 10%, 20% ...

Get PriceEmail Inquiry

Top PDF Strength and Durability Properties of Concrete ...

In construction Industry, consumption of cement is increasing day by day as well as cost is also increasing so to reduce the consumption of cement, partial replacement with Metakaolin and Marble powder was done in this study. Metakaolin is a calcinied clay and easily available in Gujarat, Maharashtra Bombay etc. It is a Dehydroxylated form of the clay mineral Kaolinite.

Get PriceEmail Inquiry

A Review on High Performance Concrete Using Mineral Fly ...

utilization. An m40 grade of concrete is used in the study and mix design was carried out according to guidelines10262 (2009). A constant 8% of Silica Fume was used as on cement replacement for all the mix. Effect of GGBS was studied by replacing cement by 30 to 50% along with PVC dust 0

Get PriceEmail Inquiry

Project on Concrete Mix Design for various grades of ...

Feb 26, 2021  Aim: To determine the mix design for M35 concrete with fly ash consisting of the following properties: Grade designation : M35 Type of cement : OPC 43 grade confirming IS 12269 Type of mineral admixture : Fly ash Maximum nominal size of aggregate : 20 Minimum water-cement ratio : 0.45 (Table 5 of IS 456:2000) Workability

Get PriceEmail Inquiry

Influence of fly ash on concrete – A systematic review ...

Jan 01, 2020  On the other hand, M35 grade of concrete mix with 30% fly ash replacement showed the highest flexural strength after 28 days. Mohammad Abushad, Misbah Danish Sabri. Comparative Study of Compressive Strength of Concrete with Fly Ash Replacement by Cement. OPC 53 grade cement is used. The experiment is carried out with M25 grade concrete.

Get PriceEmail Inquiry

3 IX September 2015

evaluated by replacing portion of cement with the flyash in M35 grade concrete. Glass fibers were also incorporated along with the fly ash to further enhance the mechanical properties. Different proportions of glass fiber starting from 0.1% to 0.4% by weight of cement in the paver block were added.

Get PriceEmail Inquiry

Experimental Study Of Palm Oil Fuel Ash As Cement ...

the results of conventional concrete of grade M35 for 3,7 and 28 days. Keywords: Experimental Study, Palm Oil Fuel Ash, Cement, Replacement, Concrete 1. INTRODUCTION With the improvement of urban areas and their foundation and the headways of apparatuses the utilization of cement

Get PriceEmail Inquiry

Service Life and Life-Cycle Assessment of Reinforced ...

were made of i) 100% OPC, ii) OPC with 30% replacement with Class F fly ash, iii) LC3, and these concrete mixes are denoted as OPC, PFA, and LC3, respectively. The OPC and PFA mixes used 53 Grade OPC conforming to the IS 12269 (2013). The LC3 was a composition of 50% clinker, OPC 31% calcined clay, 15% limestone, and gypsum 4%

Get PriceEmail Inquiry

INVESTIGATION ON FLY ASH AS A PARTIAL CEMENT REPLACEMENT ...

Jun 16, 2017  The stress-strain relations of fly ash-based concrete fit well with the expression developed for ordinary Portland cement concrete. 10. [1] CHAPTER 1 INTRODUCTION After wood, concrete is the most often used material by the community. Concrete is conventionally produced by using the ordinary Portland cement (OPC) as the Primary binding Material.

Get PriceEmail Inquiry

Compressive Strength and Elastic Modulus of Concretes with ...

strength was lower that of OPC concrete when slag replaced 80% of OPC in the concrete. Similarly, Hui-Shen et al. [5] concluded that a slag replacement level of 15–30% was optimal dosage to get the same strength as in OPC concrete at 28 days. The dosage of fly ash is generally less than 40% by weight of cement to get the same compressive ...

Get PriceEmail Inquiry

IRJET-Volume3 Issue7

Jul 07, 2016  Study compressive strength characteristics of concrete by partially replacing of OPC cement by Fly Ash with grade M35 along with partial replacement of Natural sand by varying percentage of Crusher Dust and Waste Marble Dust-Prarthita Basu. 445: Data converters for Scalable CMOS mixed signal Systems for VLSI-Tushar Shrinath, Deepak Kumar. 446

Get PriceEmail Inquiry

Can we mix OPC and PPC cement for concrete? - Quora

There is no problem to mix OPC and PPC technically if you will select right proportion to achieve desired compressive strength and durability parameters according to the structural requirement. PPC is batched by blending OPC cement with pozzolonic...

Get PriceEmail Inquiry

(PDF) Additive to Cement-A Pozzolanic Material-Fly Ash

The use of fly ash as an added material by [5] gives the strength of concrete and research by [6] who replaced part of the cement with fly ash concluded that by replacing part of the cement by fly ...

Get PriceEmail Inquiry

Studies of carbonation process in nanoparticles modified ...

Aug 20, 2020  The casting of four different types of M35 grade concrete mixes such as FA concrete (FA), TiO 2 nanoparticles modified fly ash concrete (FAT), CaCO 3 nanoparticles modified fly ash concrete (FAC) and equal mix of TiO 2:CaCO 3 nanoparticles modified fly ash concrete (FATC) were prepared as per IS 8112:1989. These nanoparticles (50–80 nm) were substitute as 2 wt% of OPC (43 grade).

Get PriceEmail Inquiry

A Review on High Performance Concrete Using Mineral Fly ...

utilization. An m40 grade of concrete is used in the study and mix design was carried out according to guidelines10262 (2009). A constant 8% of Silica Fume was used as on cement replacement for all the mix. Effect of GGBS was studied by replacing cement by 30 to 50% along with PVC dust 0

Get PriceEmail Inquiry

Fly Ash as a Partial Replacement of Cement in Concrete and ...

Jan 16, 2015  Fly Ash as a Partial Replacement of Cement in Concrete and Durability Study of Fly Ash in Acidic (H2so4) â#x20AC;Ś Table 4.4.13: Reduction

Get PriceEmail Inquiry

1. Civil - IJCSEIERD-STRENGTH PROPERTIES OF CONCRETE

conventional OPC mortar along with rendering maximum cement replacement for better economy of concrete work. Pawan kalla et al. [8] : Studied the flexural strength, mechanical properties along with micro-structure of cement binders using wollastonite as cement replacement. The investigation determined the influence of wollastonite and fly ash

Get PriceEmail Inquiry